Ever since the
World's Fair opened, Gus Wilson had been saying that he was going to take a
day off and get a preview of what the world is going to be like tomorrow.
But the Model Garage was even busier than usual all summer, so Gus kept
putting off his holiday.
Autumn was well
under way when his partner Joe Clark, who had been to the Fair a half dozen
times, built a fire under Gus with the observation that if he didn't get a
move on he'd find the big show closed and boarded up when he finally got to
it. Only then did Gus break down and say that he'd go the following day.
So the next morning he left home in his car at about his usual time, headed
for the Fair. First, however, he took a look-in at the Model Garage.
"Just wanted to
make sure that everything's going along all right," he told Joe with a
slightly sheepish grin on his face.
"On your way,
Gus!" his partner said coldly. "Beat it! Get the heck out of here!
There's a lot worth looking at over there at the Fair, and you're wanting
time."
Gus grinned, and
started filling his gas tank at the pump. Before he had finished, a
business coupe stopped beside him, and when he looked up he saw that it was
driven by Harry Meyers, a drug salesman who always stos at the Model Garage
for servicing when he is in town.
"Good morning!"
Gus said. "Joe will take care of you in just a moment. I'm taking the day
off. Going to the Fair."
"Swell!" Meyers
approved. "But, say - have you got just a minute to spare? I'm having
trouble with my car, and I've got a busy day ahead of me."
Gus hesitated.
"What kind of trouble?" he asked.
"Starting
trouble. And I can't understand it - never had any before, with this bus.
I had to stop and get some gas at a filling station about five miles down
the road - couldn't make it to your place. When I tried to start - nothing
stirring! The two fellows at the filling station took a look at the wiring,
but couldn't find anything wrong. Then a grocery boy came along in a
delivery wagon, and I got him to push me until I could get started again."
"Switch off your
engine," Gus said.. "All right. Now try to start it again."
Meyers stepped
on his starter. Nothing happened.
"Humph!" Gus
grunted. "Did those fellows at the filling station do anything to your car
except fill your gas tank?"
"They checked
the oil and water, the way they always do, but I didn't need either."
Gus raised the
side of the hood nearest to him. "Try her again."
Meyers stepped
on the starter again. Nothing happened, except that under the hood,
somewhere on the side of the engine away from him, Gus saw a spark flash.
"Wait a minute,"
he said. He closed his side of the hood, walked around the car, and raised
the other side. "Now again."
Again Meyers
stepped on the starter. And again the spark flashed. This time Gus saw
where and why it flashed. The bayonet-type oil-gauge rod, instead of having
been returned to its proper position after the oil had been checked had been
left lying across the starter, with one end resting against as exposed
starter-switch terminal. Whenever the circuit was closed by the starter
pedal being pressed down, the exposed terminal became "live," causing the
spark Gus had noticed, and grounding out the starter.
Gus pushed the
oil-gauge rod back into the place without saying anything. "Once more," he
then told Meyers. This time the engine took off perfectly.
"You're all
right now," Gus said. "No damage done."
Meyers wanted to
know the cause of the trouble, so Gus had to tell him.
"Well," he
concluded, "now you're fixed up, I'm off for the...."Morning, Doc!"
"Good morning,
Gus," Dr. Marvin said, getting out of his car. "I didn't expect to see you
here. You said that you were going to take a look in at the Fair today."
"No I am," Gus
told him. "I'm just starting. What's the matter, Doc? You look sort of
worried."
"Well," the
doctor said, "I don't want to bother you about it on your day off, but these
brakes of mine still are a long way from being right. They worked well
enough for a while after you fixed them yesterday afternoon, but this
morning they're so bad again that I'm afraid to drive with them."
"I didn't have
any more trouble for about a week," Dr. Marvin said.
"And then you
had some more. Air in the lines again. Then the same thing again
yesterday. Well, I'm going to find that trouble right now! You take my bus
to make your calls this morning, Doc. By the time you get back from them
I'll have your brakes fixed or I'll have blown out a couple of little gray
cells trying!"
Dr. Marvin
protested to no avail.
"I'll have
plenty of time at the Fair," said Gus. "Every one tells me that the evening
is the best time to enjoy yourself over there."
Finally Dr.
Marvin drove off in Gus's car and Gus drove the doctor's car into the shop.
While he was changing into overalls, Joe Clark came in. "Might have known
it!" he exclaimed disgustedly. "By jiggers, you're the most provoking , man
I ever knew, I'll..."
"Don't stand
there gassing, Joe," Gus told him. "I want to get these brakes fixed, and
then be on my way."
Joe shrugged his
shoulders helplessly and went back into the office. "Come on, Harry," Gus
said to the grease monkey. "We're going to take this hydraulic system
apart."
They took the
system apart, but Gus couldn't fine anything the matter with it. The
cylinders and cups were in perfect condition, and there were no leaks. So
they reassembled it, and found that the brakes worked perfectly.
"Which," Gus
said, "means nothing at all. Each time I've worked on them, those brakes
here seemed in perfect condition when I finished, but they went bad again.
I'm going to take this bus out and drive it for a while and see what
happens."
Gus was back
within a half hour, and as soon as he drove into the shop Harry saw that he
was good and sore. "Same damn thing over again!" he snapped as he got out.
"Air in the lines, so the brakes can't release properly. By gosh, it's got
me stumped!"
He took his pipe
out of his pocket, and walked around the rear end of the car toward his
workbench, in search of his tobacco. "What's this?" he said stopping.
"The tall light
is burning. I'll have to check that stop-light switch."
He raised the
hood, and with a quick glance located the switch, mounted on the master
cylinder of the hydraulic system. Harry, always anxious to be helpful,
reached in to make certain that it was fastened securely in its place, and
jerked his hand away with a yell of "Ouch!
"What's the
matter with you?" Gus said sympathetically.
"I burnt my
fingers!" Harry moaned, "Say, that blamed switch is red-hot!"
"Hot?" said
Gus. He touched a forefinger to his tongues, and then to the switch. "So
it is - and the cylinder is hot, too," He took off the cylinder's filler
cap, peered in and saw that the brake fluid was bubbling.
"First time I've
ever seen that happen."
He took the
switch off, checked it carefully, and found that sometimes it shorted.
"So that's the
answer," he said. "See what's been happening, Harry? Sometimes that switch
would short, and get so hot that it would heat up the metal around it so
much that the fluid would boil. The boiling oil periodically put bubbles
into the lines. I'm going to get washed up. When Dr. Marvin comes in, you
tell him about it."
Ten minutes
later, Gus was cleaned up again and getting into his car, when an
easy-to-look-at young woman drove a snappy little roadster up to the shop
door.
"Well, now, Miss Smith," Gus
said, "I'd certainly like to be able to help you - especially as you're a
friend of Peggy's. But, honestly, I can't do anything with your car
today. I've been trying to get away from here ever since
eight o'clock this morning."
"Oh, that's
terrible!" Miss Smith said, in a tone which made Gus fell like a heartless
brute. "I drove down to the city this morning, and it has taken me over two
hours to get back here. Every few miles my car just stops. I've had it in
three garages."
"Well," Gus
weakened, "I'll take a quick look. But I've got to hurry. Let's see.
Suppose we take a little ride and test her out." Miss Smith moved over so
that he could drive. He drove up the road for a mile. The car was running
perfect. Then he turned back. They came to a place where the road had
been torn up, and Gus slowed down going over the rough spot. When he
stepped on the accelerator pedal the engine suddenly went dead.
"There!" Miss
Smith said triumphantly. "That's just what it did all morning."
Gus got out,
raised the hood, and made an examination that disclosed nothing. Leaving
the hood raised, he stretched his bulky length on the fender, grasping the
nearest radiator brace rod to steady himself. "Now you drive along slow,"
he directed, "and I'll see what I can see."
The came to
another rough spot on the road. The driver slowed down to take the bumps,
then stepped on the gas again. Once more the engine went dead.
"Hold on, I've
got it," called out Gus. "Well I'll be...!"
The car came to
a halt at the side of the road. Gus climbed back to earth. "I've heard of
fuses blowing out, and tires blowing out, but here's a 'blow-out' that's new
to me. Know anything about, cars, Miss Smith?"
"A little,"
"Well, look."
She got out and obeyed.
"See this wire?
That's the lead to the coil there that makes the spark in your spark plugs.
That wire is an old one that the insulation has rotted on. It's much too
long, too. See where it's cracked here, near the coil terminal? The
wire's broken under that crack. When you hit those bumps back there, they
made the whole wire bend downward, and the wind from the fan held it down.
That broke the connection, shutting off the motor. When the car stopped,
the fan stopped blowing on the wire. It sprang back up like it is now
restoring the connection. Let's get going, and I'll be on my way to the
Fair!"
"Oh, that will
be wonderful!" Miss Smith said, "Be sure to see - "
She talked about
the Fair until they got back to the garage. When they drove up, Gus was
surprised to see that Joe Clark and a state trooper he didn't know were
standing near his car, both looking serious. "Here he is now!" Joe said.
"You're wanted
down at the substation, Mr. Wilson," the trooper said. "Right away! Let's
go!" He got on his motor cycle. "Follow me - and keep close!"
"What the heck's
all this about?" Gus demanded.
"Orders!" said
the trooper. "Hurry up!"
"Harry!" Gus
called. Harry came out. "See this wire leading to the ignition coil. It's
broken. Fix it up for this young lady. Now, Joe..."
The engine of
the trooper's motor cycle roared.
"You'd better
go, Gus," Joe said. "I guess it's something important."
Gus got into his
car, and followed the trooper. As soon as they were on the road, his escort
speeded up to forty-five and opened his siren all the way. They sped
through the center of town, then down the road to the State Police
substation
As they pulled
up at the door, Gus saw Trooper Jerry Corcoran come out, a wide grin on his
brown face. Gus's escort was grinning, too.
"We've had a
serious complaint against you, Gus," Jerry said. "From a fellow named Joe
Clark. He called up and reported that you have been loitering around his
garage all morning, and asked us to see that you left town. If you know
what's good for you, you'll keep right on going - all the way to the World's
Fair!"
"Well," Gus
said, "if that's the way the authorities feel about it, I guess maybe I
will!"
END
